Abstract
In the current paper, the behavior of zinc oxide/SAE50 nano lubricant as a part of the new generation of coolants and lubricants is examined using response surface method (RSM). The data used in this study were viscosity at dissimilar volume concentrations (0–1.5%) and temperatures (5–50 °C) for dissimilar shear rate values. Therefore, sensitivity analysis based on variation of nanoparticle (NP) concentration and temperature was also implemented. The findings revealed that enhancing the volume fraction (φ) exacerbates the viscosity sensitivity to temperature. Given the noteworthy deviance between the experimental viscosity and the data forecasted by existing classical viscosity correlations, a novel regression model is gained. R2 and adj-R2 for this model were calculated as 0.9966 and 0.9965, respectively, which represent a very good prediction with a standard deviation of 3%.
Issue Section:
Petroleum Engineering
References
1.
Meng
, X.
, and Yang
, D.
, 2019
, “Critical Review of Stabilized Nanoparticle Transport in Porous Media
,” ASME J. Energy Resour. Technol.
, 141
(7
), p. 070801
. 10.1115/1.40419292.
Abdollahzadeh Jamalabadi
, M. Y.
, Ghasemi
, M.
, Alamian
, R.
, Wongwises
, S.
, Afrand
, M.
, and Shadloo
, M. S.
, 2019
, “Modeling of Subcooled Flow Boiling With Nanoparticles Under the Influence of a Magnetic Field
,” Symmetry
, 11
(10
), p. 1275
. 10.3390/sym111012753.
Hassan
, M. A. M.
, Abdel-Hameed
, H. M.
, and Mahmoud
, O. E.
, 2019
, “Experimental Investigation of the Effect of Nanofluid on Thermal Energy Storage System Using Clathrate
,” ASME J. Energy Resour. Technol.
, 141
(4
), p. 042003
. 10.1115/1.40420044.
Rahimi
, A.
, Kasaeipoor
, A.
, Amiri
, A.
, Doranehgard
, M. H.
, Malekshah
, E. H.
, and Kolsi
, L.
, 2018
, “Lattice Boltzmann Method Based on Dual-MRT Model for Three-Dimensional Natural Convection and Entropy Generation in CuO–Water Nanofluid Filled Cuboid Enclosure Included With Discrete Active Walls
,” Comput. Math. Appl.
, 75
(5
), pp. 1795
–1813
. 10.1016/j.camwa.2017.11.0375.
Abdollahzadeh Jamalabadi
, M. Y.
, Alamian
, R.
, Yan
, W.-M.
, Li
, L. K.
, Leveneur
, S.
, and Safdari Shadloo
, M.
, 2019
, “Effects of Nanoparticle Enhanced Lubricant Films in Thermal Design of Plain Journal Bearings at High Reynolds Numbers
,” Symmetry
, 11
(11
), p. 1353
. 10.3390/sym111113536.
Siavashi
, M.
, and Doranehgard
, M. H.
, 2017
, “Particle Swarm Optimization of Thermal Enhanced Oil Recovery From Oilfields With Temperature Control
,” Appl. Therm. Eng.
, 123
, pp. 658
–669
. 10.1016/j.applthermaleng.2017.05.1097.
Schatte
, G. A.
, Kohlhepp
, A.
, Gschnaidtner
, T.
, Wieland
, C.
, and Spliethoff
, H.
, 2018
, “Heat Transfer to Supercritical Water in Advanced Power Engineering Applications: An Industrial Scale Test Rig
,” ASME J. Energy Resour. Technol.
, 140
(6
), p. 062002
. 10.1115/1.40396108.
Rashidi
, M. M.
, Nasiri
, M.
, Shadloo
, M. S.
, and Yang
, Z.
, 2017
, “Entropy Generation in a Circular Tube Heat Exchanger Using Nanofluids: Effects of Different Modeling Approaches
,” Heat Transfer Eng.
, 38
(9
), pp. 853
–866
. 10.1080/01457632.2016.12119169.
Sarafraz
, M.
, Shadloo
, M. S.
, Tian
, Z.
, Tlili
, I.
, Alkanhal
, T. A.
, Safaei
, M. R.
, Goodarzi
, M.
, and Arjomandi
, M.
, 2019
, “Convective Bubbly Flow of Water in an Annular Pipe: Role of Total Dissolved Solids on Heat Transfer Characteristics and Bubble Formation
,” Water
, 11
(8
), p. 1566
. 10.3390/w1108156610.
Venkatesan
, S. P.
, and Kadiresh
, P. N.
, 2018
, “Combustion Performance Study of Aqueous Aluminum Oxide Nanofluid Blends in Compression Ignition Engine
,” ASME J. Energy Resour. Technol.
, 141
(4
), p. 042203
. 10.1115/1.404208611.
Mabood
, F.
, Ibrahim
, S.
, Rashidi
, M.
, Shadloo
, M.
, and Lorenzini
, G.
, 2016
, “Non-uniform Heat Source/Sink and Soret Effects on MHD Non-Darcian Convective Flow Past a Stretching Sheet in a Micropolar Fluid With Radiation
,” Int. J. Heat Mass Transfer
, 93
, pp. 674
–682
.12.
Nasiri
, H.
, Jamalabadi
, M. Y. A.
, Sadeghi
, R.
, Safaei
, M. R.
, Nguyen
, T. K.
, and Shadloo
, M. S.
, 2019
, “A Smoothed Particle Hydrodynamics Approach for Numerical Simulation of Nano-fluid Flows
,” J. Therm. Anal. Calorim.
, 135
(3
), pp. 1733
–1741
. 10.1007/s10973-018-7022-413.
Safaei
, M. R.
, Ahmadi
, G.
, Goodarzi
, M. S.
, Safdari Shadloo
, M.
, Goshayeshi
, H. R.
, and Dahari
, M.
, 2016
, “Heat Transfer and Pressure Drop in Fully Developed Turbulent Flows of Graphene Nanoplatelets–Silver/Water Nanofluids
,” Fluids
, 1
(3
), p. 20
. 10.3390/fluids103002014.
Siavashi
, M.
, Karimi
, K.
, Xiong
, Q.
, and Doranehgard
, M. H.
, 2019
, “Numerical Analysis of Mixed Convection of Two-Phase Non-Newtonian Nanofluid Flow Inside a Partially Porous Square Enclosure With a Rotating Cylinder
,” J. Therm. Anal. Calorim.
, 137
, pp. 267
–287
.15.
Nicodemus
, J. H.
, Huang
, X.
, Dentinger
, E.
, Petitt
, K.
, and Smith
, J. H.
, 2019
, “Effects of Baffle Width on Heat Transfer to an Immersed Coil Heat Exchanger: Experimental Optimization
,” ASME J. Energy Resour. Technol.
, 142
(5
), p. 050901
. 10.1115/1.404553816.
Bozorg
, M. V.
, Doranehgard
, M. H.
, Hong
, K.
, and Xiong
, Q.
, 2020
, “CFD Study of Heat Transfer and Fluid Flow in a Parabolic Trough Solar Receiver With Internal Annular Porous Structure and Synthetic Oil–Al2O3 Nanofluid
,” Renewable Energy
, 145
, pp. 2598
–2614
.17.
Khodadadi
, H.
, Aghakhani
, S.
, Majd
, H.
, Kalbasi
, R.
, Wongwises
, S.
, and Afrand
, M.
, 2018
, “A Comprehensive Review on Rheological Behavior of Mono and Hybrid Nanofluids: Effective Parameters and Predictive Correlations
,” Int. J. Heat Mass Transfer
, 127
, pp. 997
–1012
. 10.1016/j.ijheatmasstransfer.2018.07.10318.
Esfe
, M. H.
, and Afrand
, M.
, 2019
, “An Updated Review on the Nanofluids Characteristics
,” J. Therm. Anal. Calorim.
, 138
(6
), pp. 4091
–4101
. 10.1007/s10973-019-08406-219.
Shahsavani
, E.
, Afrand
, M.
, and Kalbasi
, R.
, 2018
, “Using Experimental Data to Estimate the Heat Transfer and Pressure Drop of non-Newtonian Nanofluid Flow Through a Circular Tube: Applicable for Use in Heat Exchangers
,” Appl. Therm. Eng.
, 129
, pp. 1573
–1581
. 10.1016/j.applthermaleng.2017.10.14020.
Toghraie
, D.
, Alempour
, S. M.
, and Afrand
, M.
, 2016
, “Experimental Determination of Viscosity of Water Based Magnetite NF for Application in Heating and Cooling Systems
,” J. Magn. Magn. Mater.
, 417
, pp. 243
–248
. 10.1016/j.jmmm.2016.05.09221.
Esfe
, M. H.
, Afrand
, M.
, Yan
, W.-M.
, Yarmand
, H.
, Toghraie
, D.
, and Dahari
, M.
, 2016
, “Effects of Temperature and Concentration on Rheological Demeanor of MWCNTs/SiO2 (20–80)-SAE40 Hybrid Nano-Lubricant
,” Int. Commun. Heat Mass Transfer
, 76
, pp. 133
–138
.22.
Sepyani
, K.
, Afrand
, M.
, and Esfe
, M. H.
, 2017
, “An Experimental Evaluation of the Effect of ZnO NPs on the Rheological Demeanor of Engine Oil
,” J. Mol. Liq.
, 236
, pp. 198
–204
. 10.1016/j.molliq.2017.04.01623.
Eshgarf
, H.
, and Afrand
, M.
, 2016
, “An Experimental Study on Rheological Demeanor of Non-Newtonian Hybrid Nano-coolant for Application in Cooling and Heating Systems
,” Exp. Therm. Fluid. Sci.
, 76
, pp. 221
–227
. 10.1016/j.expthermflusci.2016.03.01524.
Afrand
, M.
, Toghraie
, D.
, and Ruhani
, B.
, 2016
, “Effects of Temperature and Nanoparticles Concentration on Rheological Demeanor of Fe3O4–Ag/EG Hybrid Nanofluid: An Experimental Study
,” Exp. Therm. Fluid. Sci.
, 77
, pp. 38
–44
. 10.1016/j.expthermflusci.2016.04.00725.
Nadooshan
, A. A.
, Esfe
, M. H.
, and Afrand
, M.
, 2017
, “Evaluation of Rheological Demeanor of 10W40 Lubricant Containing Hybrid Nano-material by Measuring Dynamic Viscosity
,” Phys. E
, 92
, pp. 47
–54
. 10.1016/j.physe.2017.05.01126.
Akbari
, M.
, Afrand
, M.
, Arshi
, A.
, and Karimipour
, A.
, 2017
, “An Experimental Study on Rheological Demeanor of Ethylene Glycol Based NF: Proposing a New Correlation as a Function of Silica Concentration and Temperature
,” J. Mol. Liq.
, 233
, pp. 352
–357
. 10.1016/j.molliq.2017.03.02027.
Esfe
, M. H.
, Afrand
, M.
, Rostamian
, S. H.
, and Toghraie
, D.
, 2017
, “Examination of Rheological Demeanor of MWCNTs/ZnO-SAE40 Hybrid Nano-lubricants Under Various Temperatures and Solid φs
,” Exp. Therm. Fluid. Sci.
, 80
, pp. 384
–390
.28.
Esfe
, M. H.
, and Afrand
, M.
, 2020
, “Predicting Thermophysical Properties and Flow Characteristics of Nanofluids Using Intelligent Methods: Focusing on ANN Methods
,” J. Therm. Anal. Calorim.
, 140
(2
), pp. 501
–525
. 10.1007/s10973-019-08789-229.
Hemmat Esfe
, M.
, Firouzi
, M.
, Rostamian
, H.
, and Afrand
, M.
, 2018
, “Prediction and Optimization of Thermophysical Properties of Stabilized Al2O3/Antifreeze NFs Using Response Surface Methodology
,” J. Mol. Liq.
, 261
, pp. 14
–20
. 10.1016/j.molliq.2018.03.06330.
Ghasemi
, N.
, and Rohani
, S.
, 2019
, “Optimization of Cyanide Removal From Wastewaters Using a New Nano-adsorbent Containing ZnO NPs and MOF/Cu and Evaluating its Efficacy and Prediction of Experimental Results With Artificial Neural Networks
,” J. Mol. Liq.
, 285
, pp. 252
–269
. 10.1016/j.molliq.2019.04.08531.
Hemmat Esfe
, M.
, Hassani Ahangar
, M. R.
, Rejvani
, M.
, Toghraie
, D.
, and Hajmohammad
, M. H.
, 2016
, “Designing an Artificial Neural Network to Forecast Dynamic Viscosity of Aqueous NF of TiO2 Using Experimental Data
,” Int. Commun. Heat Mass Transfer
, 75
, pp. 192
–196
. 10.1016/j.icheatmasstransfer.2016.04.00232.
Ahmadi
, M. H.
, Tatar
, A.
, Seifaddini
, P.
, Ghazvini
, M.
, Ghasempour
, R.
, and Sheremet
, M. A.
, 2018
, “Thermal Conductivity and Dynamic Viscosity Modeling of Fe2O3/Water NF by Applying Various Connectionist Approaches
,” Numer. Heat Transfer, Part A
, 74
(6
), pp. 1301
–1322
. 10.1080/10407782.2018.150509233.
Hemmat Esfe
, M.
, Saedodin
, S.
, Sina
, N.
, Afrand
, M.
, and Rostami
, S.
, 2015
, “Designing an Artificial Neural Network to Forecast Thermal Conductivity and Dynamic Viscosity of Ferromagnetic NF
,” Int. Commun. Heat Mass Transfer
, 68
, pp. 50
–57
. 10.1016/j.icheatmasstransfer.2015.06.01334.
Afrand
, M.
, Ahmadi Nadooshan
, A.
, Hassani
, M.
, Yarmand
, H.
, and Dahari
, M.
, 2016
, “Predicting the Viscosity of Multi-walled Carbon Nanotubes/Water NF by Developing an Optimal Artificial Neural Network Based on Experimental Data
,” Int. Commun. Heat Mass Transfer
, 77
, pp. 49
–53
. 10.1016/j.icheatmasstransfer.2016.07.00835.
Vakili
, M.
, Khosrojerdi
, S.
, Aghajannezhad
, P.
, and Yahyaei
, M.
, 2017
, “A Hybrid Artificial Neural Network-Genetic Algorithm Modeling Approach for Viscosity Estimation of Graphene Nanoplatelets NF Using Experimental Data
,” Int. Commun. Heat Mass Transfer
, 82
, pp. 40
–48
. 10.1016/j.icheatmasstransfer.2017.02.00336.
Dalkilic
, A. S.
, Çebi
, A.
, Çelen
, A. İ.
, Yıldız
, O.
, Acikgoz
, O.
, Jumpholkul
, C.
, Bayrak
, M. B.
, Surana
, K.
, and Wongwises
, S.
, 2016
, “Prediction of Graphite NFs’ Dynamic Viscosity by Means of Artificial Neural Networks
,” Int. Commun. Heat Mass Transfer
, 73
, pp. 33
–42
. 10.1016/j.icheatmasstransfer.2016.02.01037.
Aminian
, A.
, 2017
, “Predicting the Effective Viscosity of NFs for the Augmentation of Heat Transfer in the Process Industries
,” J. Mol. Liq.
, 229
, pp. 300
–308
. 10.1016/j.molliq.2016.12.07138.
Ansari
, H. R.
, Zarei
, M. J.
, Sabbaghi
, S.
, and Keshavarz
, P.
, 2018
, “A New Comprehensive Model for Relative Viscosity of Various NFs Using Feed-Forward Back-Propagation MLP Neural Networks
,” Int. Commun. Heat Mass Transfer
, 91
, pp. 158
–164
. 10.1016/j.icheatmasstransfer.2017.12.01239.
Longo
, G. A.
, Zilio
, C.
, Ortombina
, L.
, and Zigliotto
, M.
, 2017
, “Application of Artificial Neural Network (ANN) for Modeling Oxide-Based NFs Dynamic Viscosity
,” Int. Commun. Heat Mass Transfer
, 83
, pp. 8
–14
. 10.1016/j.icheatmasstransfer.2017.03.00340.
Hemmat Esfe
, M.
, Abbasian Arani
, A. A.
, and Esfandeh
, S.
, 2018
, “Improving Engine Oil Lubrication in Light-Duty Vehicles by Using of Dispersing MWCNT and ZnO NPs in 5W50 as Viscosity Index Improvers (VII)
,” Appl. Therm. Eng.
, 143
, pp. 493
–506
. 10.1016/j.applthermaleng.2018.07.03441.
Darbari
, B.
, Rashidi
, S.
, and Abolfazli Esfahani
, J.
, 2016
, “Sensitivity Analysis of Entropy Generation in NF Flow Inside a Channel by Response Surface Methodology
,” Entropy.
, 18
(2
), p. 52
. 10.3390/e1802005242.
Ahamed
, M. M.
, Basha
, S. J.
, and Prasad
, B. D.
, 2019
, Emerging Trends in Mechanical Engineering
, Springer
, pp. 153
–164
.43.
Giovanni
, M.
, 1983
, “Response Surface Methodology and Product Optimization
,” Food Technol.
, 37
(11
), pp. 41
–45
.44.
Rashidi
, S.
, Bovand
, M.
, Rahbar
, N.
, and Esfahani
, J. A.
, 2018
, “Steps Optimization and Productivity Enhancement in a NF Cascade Solar Still
,” Renewable Energy.
, 118
, pp. 536
–545
. 10.1016/j.renene.2017.11.04845.
Vahedi
, S. M.
, Pordanjani
, A. H.
, Wongwises
, S.
, and Afrand
, M.
, 2019
, “On the Role of Enclosure Side Walls Thickness and Heater Geometry in Heat Transfer Enhancement of Water–Al 2 O 3 NF in Presence of a Magnetic Field
,” J. Thermal Analysis Calorimetry.
, 138
, pp. 679
–696
.46.
Vahedi
, S. M.
, Pordanjani
, A. H.
, Raisi
, A.
, and Chamkha
, A. J.
, 2019
, “Sensitivity Analysis and Optimization of MHD Forced Convection of a Cu-Water NF Flow Past a Wedge
,” Eur. Phys. J. Plus
, 134
(3
), p. 124
. 10.1140/epjp/i2019-12537-x47.
Pordanjani
, A. H.
, Vahedi
, S. M.
, Rikhtegar
, F.
, and Wongwises
, S.
, 2019
, “Optimization and Sensitivity Analysis of Magneto-Hydrodynamic Natural Convection NF Flow Inside a Square Enclosure Using Response Surface Methodology
,” J. Therm. Anal. Calorim.
, 135
(2
), pp. 1031
–1045
. 10.1007/s10973-018-7652-648.
Pordanjani
, A. H.
, Vahedi
, S. M.
, Aghakhani
, S.
, Afrand
, M.
, Öztop
, H. F.
, and Abu-Hamdeh
, N.
, 2019
, “Effect of Magnetic Field on Mixed Convection and Entropy Generation of Hybrid NF in an Inclined Enclosure: Sensitivity Analysis and Optimization
,” Eur. Phys. J. Plus
, 134
(8
), p. 412
.49.
Rejvani
, M.
, Alipour
, A.
, Vahedi
, S. M.
, Chamkha
, A. J.
, and Wongwises
, S.
, 2019
, “Optimal Characteristics and Heat Transfer Efficiency of SiO2/Water NF for Application of Energy Devices: A Comprehensive Study
,” Int. J. Energy Res.
, 43
(14
), pp. 8548
–8571
.50.
Esfe
, M. H.
, Mahian
, O.
, Hajmohammad
, M. H.
, and Wongwises
, S.
, 2018
, “Design of a Heat Exchanger Working With Organic NFs Using Multi-objective Particle Swarm Optimization Algorithm and Response Surface Method
,” Int. J. Heat Mass Transfer.
, 119
, pp. 922
–930
. 10.1016/j.ijheatmasstransfer.2017.12.009Copyright © 2020 by ASME
You do not currently have access to this content.
