Abstract

Proton exchange membrane (PEM) electrolyzer can produce gases at the pressure suitable for direct storage into metal hydride cylinders, bypassing compressors, and other auxiliary components. For direct storage into metal hydride containers, hydrogen gas's pressure and flowrate must be well controlled. However, the PEM electrolyzer's time-variant and nonlinear dynamics call for an adaptive control to maintain its output performance. Therefore, in this paper, a model-free relay-feedback autotuning approach is proposed to tune a proportional-integral (PI) controller online. The controller determines the voltage supply to the electrolyzer to track a certain current setpoint, which corresponds to a constant hydrogen production rate. A gain scheduling approach is developed to pick up the right controller gain at different setpoints, minimizing the tuning frequency. A self-assessment algorithm is developed to determine the situations where the autotuner should activate to update the PI parameters, thus allowing the control system to be tuned autonomously. The autotuning PI control is successfully tested with a PEM electrolyzer setup. Experiment results showed that autotuner with gain scheduling could tune the controller parameters producing a desired transient behavior and is adaptive to the variations in setpoint and operating conditions.

References

1.
Prinz
,
F. B.
,
O'Hayre
,
R.
,
Cha
,
S.-W.
, and
Colella
,
W.
,
2016
,
Fuel Cell Fundamentals
,
Wiley
,
Hoboken, NJ
.
2.
Barbir
,
F.
,
2005
,
PEM Fuel Cells: Theory and Practice
,
Elsevier Academic
,
London/Amsterdam, UK/The Netherlands
.
3.
Kim
,
S. H.
,
Miesse
,
C. M.
,
Lee
,
H. B.
,
Chang
,
I. W.
,
Hwang
,
Y. S.
,
Jang
,
J. H.
, and
Cha
,
S. W.
,
2014
, “
Ultra Compact Direct Hydrogen Fuel Cell Prototype Using a Metal Hydride Hydrogen Storage Tank for a Mobile Phone
,”
Appl. Energy
,
134
, pp.
382
391
.10.1016/j.apenergy.2014.08.019
4.
Marangio
,
F.
,
Santarelli
,
M.
, and
Cali
,
M.
,
2009
, “
Theoretical Model and Experimental Analysis of a High Pressure PEM Water Electrolyser for Hydrogen Production
,”
Int. J. Hydrogen Energy
,
34
(
3
), pp.
1143
1158
.10.1016/j.ijhydene.2008.11.083
5.
Keow
,
A. L. J.
,
Mayhall
,
A.
,
Cescon
,
M.
, and
Chen
,
Z.
,
2020
, “
Active Disturbance Rejection Control of Metal Hydride Hydrogen Storage
,”
Int. J. Hydrogen Energy
, in press.10.1016/j.ijhydene.2020.09.169
6.
Ito
,
H.
,
Maeda
,
T.
,
Nakano
,
A.
, and
Takenaka
,
H.
,
2011
, “
Properties of Nafion Membranes Under PEM Water Electrolysis Conditions
,”
Int. J. Hydrogen Energy
,
36
(
17
), pp.
10527
10540
.10.1016/j.ijhydene.2011.05.127
7.
Corengia
,
M.
, and
Torres
,
A. I.
,
2018
, “
Two-Phase Dynamic Model for PEM Electrolyzer
,” Computer Aided Chemical Engineering, Vol. 44,
Elsevier
,
Amsterdam, The Netherlsnds
, pp.
1435
1440
.
8.
Aubras
,
F.
,
Deseure
,
J.
,
Kadjo
,
J.-J.
,
Dedigama
,
I.
,
Majasan
,
J.
,
Grondin-Perez
,
B.
,
Chabriat
,
J.-P.
, and
Brett
,
D.
,
2017
, “
Two-Dimensional Model of Low-Pressure PEM Electrolyser: Two-Phase Flow Regime, Electrochemical Modelling and Experimental Validation
,”
Int. J. Hydrogen Energy
,
42
(
42
), pp.
26203
26216
.10.1016/j.ijhydene.2017.08.211
9.
Hernández-Gómez
,
Á.
,
Ramirez
,
V.
,
Guilbert
,
D.
, and
Saldivar
,
B.
,
2020
, “
Development of an Adaptive Static-Dynamic Electrical Model Based on Input Electrical Energy for PEM Water Electrolysis
,”
Int. J. Hydrogen Energy
,
45
(
38
), pp.
18817
18830
.10.1016/j.ijhydene.2020.04.182
10.
Görgün
,
H.
,
2006
, “
Dynamic Modelling of a Proton Exchange Membrane (PEM) Electrolyzer
,”
Int. J. Hydrogen Energy
,
31
(
1
), pp.
29
38
.10.1016/j.ijhydene.2005.04.001
11.
Abdin
,
Z.
,
Webb
,
C.
, and
Gray
,
E.
,
2015
, “
Modelling and Simulation of a Proton Exchange Membrane (PEM) Electrolyser Cell
,”
Int. J. Hydrogen Energy
,
40
(
39
), pp.
13243
13257
.10.1016/j.ijhydene.2015.07.129
12.
Lebbal
,
M.
, and
Lecœuche
,
S.
,
2009
, “
Identification and Monitoring of a PEM Electrolyser Based on Dynamical Modelling
,”
Int. J. Hydrogen Energy
,
34
(
14
), pp.
5992
5999
.10.1016/j.ijhydene.2009.02.003
13.
Schei
,
T. S.
,
1994
, “
Automatic Tuning of PID Controllers Based on Transfer Function Estimation
,”
Automatica
,
30
(
12
), pp.
1983
1989
.10.1016/0005-1098(94)90060-4
14.
Takatsu
,
H.
,
Kawano
,
T.
, and
Kitano
,
K.
,
1991
, “
Intelligent Self-Tuning PID Controller
,”
IFAC Proc. Vols.
,
24
(
1
), pp.
11
15
.10.1016/S1474-6670(17)51289-6
15.
Yamamoto
,
T.
,
Fujii
,
K.
, and
Kaneda
,
M.
,
1998
, “
Design and Implementation of a Self-Tuning PID Controller
,”
IFAC Proc. Vols.
,
31
(
22
), pp.
59
64
.10.1016/S1474-6670(17)35921-9
16.
McCormack
,
A.
, and
Godfrey
,
K.
,
1998
, “
Rule-Based Autotuning Based on Frequency Domain Identification
,”
IEEE Trans. Control Syst. Technol.
,
6
(
1
), pp.
43
61
.10.1109/87.654876
17.
Åström
,
K. J.
,
1990
, “
Application of Robust and Adaptive Pole Placement
,”
Int. J. Adapt Control Signal Process.
,
4
(
2
), pp.
99
110
.10.1002/acs.4480040204
18.
Åström
,
K.
, and
Hägglund
,
T.
,
1988
, “
A New Auto-Tuning Design
,”
IFAC Proc. Vols.
,
21
(
7
), pp.
141
146
.10.1016/S1474-6670(17)53815-X
19.
Åström
,
K.
, and
Hägglund
,
T.
,
1984
, “
Automatic Tuning of Simple Regulators With Specifications on Phase and Amplitude Margins
,”
Automatica
,
20
(
5
), pp.
645
651
.10.1016/0005-1098(84)90014-1
20.
Hang
,
C.
,
Astrom
,
K.
, and
Wang
,
Q.
,
2002
, “
Relay Feedback Auto-Tuning of Process Controllers—A Tutorial Review
,”
J. Process Control
,
12
(
1
), pp.
143
162
.10.1016/S0959-1524(01)00025-7
21.
Ho
,
W. K.
,
Hang
,
C. C.
, and
Cao
,
L. S.
,
1995
, “
Tuning of PID Controllers Based on Gain and Phase Margin Specifications
,”
Automatica
,
31
(
3
), pp.
497
502
.10.1016/0005-1098(94)00130-B
22.
Wang
,
Y.-G.
, and
Shao
,
H.-H.
,
1999
, “
PID Autotuner Based on Gain- and Phase-Margin Specifications
,”
Ind. Eng. Chem. Res.
,
38
(
8
), pp.
3007
3012
.10.1021/ie9808007
23.
Ho
,
W.
,
Hang
,
C.
, and
Cao
,
L.
,
1993
, “
Tuning of PID Controllers Based on Gain and Phase Margin Specifications
,”
IFAC Proc. Vols.
,
26
(
2
), pp.
199
202
.10.1016/S1474-6670(17)48453-9
24.
Wang
,
L.
,
Xiao
,
K.
,
de Lillo
,
L.
,
Empringham
,
L.
, and
Wheeler
,
P.
,
2014
, “
PI Controller Relay Auto-Tuning Using Delay and Phase Margin in PMSM Drives
,”
Chin. J. Aeronaut.
,
27
(
6
), pp.
1527
1537
.10.1016/j.cja.2014.10.019
25.
de Arruda
,
G.
, and
Barros
,
P.
,
2003
, “
Relay-Based Gain and Phase Margins PI Controller Design
,”
IEEE Trans. Instrum. Meas.
,
52
(
5
), pp.
1548
1553
.10.1109/TIM.2003.817147
26.
Chen
,
Z.
,
Naizer
,
B.
, and
Kang
,
Y.
,
2016
, “
Proppant-Conveyor Automation System with Cascade Control in Hydraulic Fracturing
,”
SPE Prod. Oper.
,
31
(
4
), pp.
310
317
.10.2118/181762-PA
27.
Carmo
,
M.
,
Fritz
,
D. L.
,
Mergel
,
J.
, and
Stolten
,
D.
,
2013
, “
A Comprehensive Review on PEM Water Electrolysis
,”
Int. J. Hydrogen Energy
,
38
(
12
), pp.
4901
4934
.10.1016/j.ijhydene.2013.01.151
28.
Guilbert
,
D.
,
Sorbera
,
D.
, and
Vitale
,
G.
,
2020
, “
A Stacked Interleaved DC-DC Buck Converter for Proton Exchange Membrane Electrolyzer Applications: Design and Experimental Validation
,”
Int. J. Hydrogen Energy
,
45
(
1
), pp.
64
79
.10.1016/j.ijhydene.2019.10.238
29.
Guida
,
V.
,
Guilbert
,
D.
,
Vitale
,
G.
, and
Douine
,
B.
,
2020
, “
Design and Realization of a Stacked Interleaved DC–DC Step-Down Converter for PEM Water Electrolysis With Improved Current Control
,”
Fuel Cells
,
20
(
3
), pp.
307
315
.10.1002/fuce.201900153
30.
Ho
,
W.
,
Gan
,
O.
,
Tay
,
E.
, and
Ang
,
E.
,
1996
, “
Performance and Gain and Phase Margins of Well-Known PID Tuning Formulas
,”
IEEE Trans. Control Syst. Technol.
,
4
(
4
), pp.
473
477
.10.1109/87.508897
31.
Åström
,
K. J.
, and
Hägglund
,
T.
,
2006
,
Advanced PID Control
,
ISA-The Instrumentation, Systems, and Automation Society, Research Triangle Park
,
NC
.
32.
Chen
,
Z.
,
Cargill
,
L.
, and
Naizer
,
B.
,
2016
, “
Auto-Tuning Tub-Level Control of Blender in Hydraulic Fracturing
,”
ASME
Paper No. DSCC2016-9848.10.1115/DSCC2016-9848
33.
Ziegler
,
J. G.
, and
Nichols
,
N. B.
,
1993
, “
Optimum Settings for Automatic Controllers
,”
ASME J. Dyn. Syst., Meas., Control
,
115
(
2B
), pp.
220
222
.10.1115/1.2899060
34.
Åström
,
K.
,
1982
,
Ziegler-Nichols Auto-Tuners
,
Department of Automatic Control, Lund Institute of Technology (LTH)
, Report No. TFRT-3167.
35.
Nise
,
N.
,
1995
,
Control Systems Engineering
,
Wiley
,
New York
.
You do not currently have access to this content.