The gas charged hydraulic accumulators under consideration are used as energy storage devices in automotive hydraulic hybrid systems. The knowledge of the state of charge (SOC) is of utmost importance for an efficient energy management of the hybrid drive-train. Since the direct measurement of the SOC is difficult and costly, an SOC estimator design is presented based on a mathematical model of the gas charged hydraulic accumulator. Two different SOC estimation strategies, a signal-based approach and an Extended Kalman-filter, are presented and compared with each other. The performance of the estimators is validated by means of measurement results of a test driving cycle.
Issue Section:
Research Papers
References
1.
Chan
, C.
, 2007
, “The State of the Art of Electric, Hybrid, and Fuel Cell Vehicles
,” Proc. IEEE
, 95
(4
), pp. 704
–718
.10.1109/JPROC.2007.8924892.
Yoong
, M. K.
, Gan
, Y. H.
, Gan
, G. D.
, Leong
, C. K.
, Phuan
, Z. Y.
, Cheah
, B. K.
, and Chew
, K. W.
, 2010
, “Studies of Regenerative Braking in Electric Vehicle
,” IEEE Conference on Sustainable Utilization and Development in Engineering and Technology
, pp. 40
–45
.3.
Pourmovahed
, A.
, Beachley
, N.
, and Fronczak
, F.
, 1992
, “Modeling of a Hydraulic Energy Regeneration System: Part I–Analytical Treatment
,” ASME J. Dyn. Syst. Meas. Control
, 114
(1
), pp. 155
–159
.10.1115/1.28964974.
Pourmovahed
, A.
, Beachley
, N.
, and Fronczak
, F.
, 1992
, “Modeling of a Hydraulic Energy Regeneration System: Part II–Experimental Program
,” ASME J. Dyn. Syst. Meas. Control
, 114
(1
), pp. 160
–165
.10.1115/1.28964985.
Ho
, T. H.
, and Ahn
, K. K.
, 2012
, “Design and Control of a Closed-Loop Hydraulic Energy-Regenerative System
,” Autom. Constr.
, 22
, pp. 444
–458
.10.1016/j.autcon.2011.11.0046.
Johri
, R.
, and Filipi
, Z.
, 2009
, “Low-Cost Pathway to Ultra Efficient City Car: Series Hydraulic Hybrid System With Optimized Supervisory Control
,” SAE Int. J. Engines
, 2
(2
), pp. 505
–520
.10.4271/2009-24-00657.
Deppen
, T. O.
, Alleyne
, A.
, Stelson
, K. A.
, and Meyer
, J. J.
, 2012
, “Optimal Energy Use in a Light Weight Hydraulic Hybrid Passenger Vehicle
,” ASME J. Dyn. Syst. Meas. Control
, 134
(4
), p. 041009
.10.1115/1.40060828.
Wu
, B.
, Lin
, C.-C.
, Filipi
, Z.
, Peng
, H.
, and Assanis
, D.
, 2004
, “Optimal Power Management for a Hydraulic Hybrid Delivery Truck
,” Veh. Syst. Dyn.
, 42
(1–2
), pp. 23
–40
.10.1080/004231104123312915629.
Filipi
, Z.
, Louca
, L.
, Daran
, B.
, Lin
, C.-C.
, Yildir
, U.
, Wu
, B.
, Kokkolaras
, M.
, Assanis
, D.
, Peng
, H.
, Papalambros
, P.
, Stein
, J.
, Szkubiel
, D.
, and Chapp
, R.
, 2004
, “Combined Optimisation of Design and Power Management of the Hydraulic Hybrid Propulsion System for the 6–6 Medium Truck
,” Int. J. Heavy Veh. Syst.
, 11
(3
), pp. 372
–402
.10.1504/IJHVS.2004.00545810.
Kaszynski
, M.
, and Sawodny
, O.
, 2011
, “Determining the Fuel Savings Potential of Parallel Hybrid Hydraulic Vehicles
,” Int. J. Powertrains
, 1
(1
), pp. 22
–42
.10.1504/IJPT.2011.04190811.
Li
, C.-T.
, and Peng
, H.
, 2010
, “Optimal Configuration Design for Hydraulic Split Hybrid Vehicles
,” American Control Conference (ACC)
, pp. 5812
–5817
.12.
Liu
, T.
, Jiang
, J.
, and Sun
, H.
, 2009
, “Investigation to Simulation of Regenerative Braking for Parallel Hydraulic Hybrid Vehicles
,” International Conference on Measuring Technology and Mechatronics Automation
, ICMTMA’09, Vol. 2
, pp. 242
–245
.13.
Oustaloup
, A.
, Mathieu
, B.
, and Lanusse
, P.
, 1995
, “The CRONE Control of Resonant Plants: Application to a Flexible Transmission
,” Eur. J. Control
, 1
(2
), pp. 113
–121
.10.1016/S0947-3580(95)70014-014.
Lemofouet
, S.
, and Rufer
, A.
, 2006
, “A Hybrid Energy Storage System Based on Compressed Air and Supercapacitors With Maximum Efficiency Point Tracking (MEPT)
,” IEEE Trans. Indus. Electron.
, 53
(4
), pp. 1105
–1115
.10.1109/TIE.2006.87832315.
Lagwankar
, K. D.
, 2013
, “Hydraulic Regenerative System for Bicycle
,” Int. J. Eng. Res. Appl.
, 3
(1
), pp. 869
–875
.16.
Deppen
, T.
, Alleyne
, A.
, Stelson
, K.
, and Meyer
, J.
, 2011
, “A Model Predictive Control Approach for a Parallel Hydraulic Hybrid Powertrain
,” American Control Conference
(ACC
), pp. 2713
–2718
.10.1109/ACC.2011.599112817.
Otis
, D. R.
, and Pourmovahed
, A.
, 1985
, “An Algorithm for Computing Nonflow Gas Processes in Gas Springs and Hydropneumatic Accumulators
,” ASME J. Dyn. Syst. Meas. Control
, 107
(93
), pp. 93
–96
.10.1115/1.314071418.
Els
, P.
, and Grobbelaar
, B.
, 1993
, “Investigation of the Time- and Temperature Dependency of Hydro-Pneumatic Suspension Systems
,” SAE Technical Paper No. 930265, pp. 55
–65
.19.
Puddu
, P.
, and Paderi
, M.
, 2013
, “Hydro-Pneumatic Accumulators for Vehicles Kinetic Energy Storage: Influence of Gas Compressibility and Thermal Losses on Storage Capability
,” Energy
, 57
(C
), pp. 326
–335
.10.1016/j.energy.2013.04.07220.
Sychev
, V. V.
, 1991
, The Differential Equations of Thermodynamics
, 2nd ed., Hemisphere Publishing Corporation and Mir Publishers
, New York and Moscow
.21.
VDI-Gesellschaft
, 2010
, VDI Heat Atlas
, 2nd ed., Springer
, Berlin, Heidelberg, Germany
.22.
Stoer
, J.
, and Burlisch
, R.
, 2002
, Introduction to Numerical Analysis
, 3rd ed., Springer
, New York
.23.
Anderson
, B.
, and Moore
, J.
, 1979
, Optimal Filtering
, Prentice-Hall
, Englewood Cliffs, NJ
.24.
Becerra
, V.
, Roberts
, P.
, and Griffiths
, G.
, 2001
, “Applying the Extended Kalman Filter to Systems Described by Nonlinear Differential-Algebraic Equations
,” Control Eng. Pract.
, 9
(3
), pp. 267
–281
.10.1016/S0967-0661(00)00110-6Copyright © 2015 by ASME
You do not currently have access to this content.
